Développement d’un procédé hybride de traitement des fumées pour la marine marchande (Thèse 2020 - 2023)
-en- Activités
traitement de l’air,
membranes,
absorption,
métaux lourds,
environnement.
-en- Publications scientifiques au M2P2
2022
Maryse Drouin, Giulia Parravicini, Samy Nasser, Philippe Moulin. Membrane Separation Used as Treatment of Alkaline Wastewater from a Maritime Scrubber Unit. Membranes, 2022, 12 (10), pp.968. ⟨10.3390/membranes12100968⟩. ⟨hal-03967086⟩ Plus de détails...
Since 1 January 2020, the sulfur content allowed in exhaust gas plume generated by marine vessels decreased to 0.5% m/m. To be compliant, a hybrid scrubber was installed on-board, working in closed loop and generating a high volume of alkaline wastewater. The alkaline water suspension was treated by a silicon carbide multitubular membrane to remove pollutants, and to allow the water discharge into the natural environment. In this paper, membrane filtration behavior was analyzed for the maritime scrubber wastewater. A range of operating parameters were obtained for several feedwater quality-respecting industrial constraints. The objective was an improvement of (I) the water recovery rate, (II) the filtration duration, and (III) the permeate quality. Thus, in high-fouling water, a low permeate flow (60 L h−1 m−2) with frequent backflushing (every 20 min) was used to maintain membrane performance over time. In terms of water quality, the suspended solids and heavy metals were retained at more than 99% and 90%, respectively. Other seawater discharge criteria in terms of suspended solids concentration, pH, and polyaromatic hydrocarbons were validated. The recommended operating conditions from laboratory study at semi-industrial scale were then implemented on a vessel in real navigation conditions with results in agreement with expectations.
Maryse Drouin, Giulia Parravicini, Samy Nasser, Philippe Moulin. Membrane Separation Used as Treatment of Alkaline Wastewater from a Maritime Scrubber Unit. Membranes, 2022, 12 (10), pp.968. ⟨10.3390/membranes12100968⟩. ⟨hal-03967086⟩
Sophie Arénillas, Maryse Drouin, Emmanuel Monnin, Philippe Moulin. Glycerin Removal from Ultrafiltration Flat Sheet Membranes by Filtration and Soaking. Journal of Membrane Science and Research, 2017, 3 (2), pp.102 - 108. ⟨10.22079/jmsr.2016.23080⟩. ⟨hal-01647166⟩ Plus de détails...
In the case of pharmaceutical processes, the presence of preservatives can be problematic and the quantity is subject to stringent standards. So, the aim of this study is to quantify the removal of glycerin contained in ultrafiltration flat sheet membranes by filtration and soaking. This is carried out over a wide range of membranes with different characteristics. The selected flat sheet membranes (with a surface of 14.5 cm²) have a Molecular Weight Cut-Off (MWCO) ranging from 5 to 60 kDa. They are made of different organic materials (polyethersulfone, regenerated cellulose and etc.) and are manufactured by different suppliers (Millipore, Sartorius, GE Osmonics, Novasep, Pall). The density and therefore the glycerin concentration measurements are carried out in filtered distilled water (dead-end filtration) and distilled water of soaking (diffusion phenomenon). This study gives experi-mental information about the glycerin quantity as a function of membrane characteristics and the position of glycerin on the membrane (skin layer and support). The various studied parameters are the removal kinetic, the filtered volume, the filtration pressure and the contact time.
Sophie Arénillas, Maryse Drouin, Emmanuel Monnin, Philippe Moulin. Glycerin Removal from Ultrafiltration Flat Sheet Membranes by Filtration and Soaking. Journal of Membrane Science and Research, 2017, 3 (2), pp.102 - 108. ⟨10.22079/jmsr.2016.23080⟩. ⟨hal-01647166⟩
Eric Serre, Sandrine Hugues, Emilia Crespo del Arco, Anthony Randriamampianina, Patrick Bontoux. Axisymmetric and three-dimensional instabilities in an Ekman boundary layer flow. International Journal of Heat and Fluid Flow, 2001, 22 (1), pp.82-93. ⟨hal-01023080⟩ Plus de détails...
Eric Serre, Sandrine Hugues, Emilia Crespo del Arco, Anthony Randriamampianina, Patrick Bontoux. Axisymmetric and three-dimensional instabilities in an Ekman boundary layer flow. International Journal of Heat and Fluid Flow, 2001, 22 (1), pp.82-93. ⟨hal-01023080⟩
Journal: International Journal of Heat and Fluid Flow
